Death of young worker leads to court for recycling company

A recycling company in South Devon has been sentenced for serious safety breaches after a worker was killed after likely being thrown from a six-tonne dumper truck. 

Ben Sewell, 30, from Dartmouth, was found lying on his back on a bank, a few metres behind the overturned dumper, on a sloping dirt track at Dittisham Recycling Centre on 21 September 2012. He was pronounced dead at the scene. 

The Health and Safety Executive (HSE) prosecuted the firm after an investigation discovered that Mr Sewell, who was single, had not been properly trained by his employer to use the vehicle. The company had also failed to properly enforce the wearing of seat belts fitted to the dumpers used by Ben and other staff. 

Plymouth Crown Court heard that HSE’s investigation uncovered a catalogue of dangers at the Dittisham Recycling site and served a total of eight Prohibition Notices on the company preventing its use of various plant and machinery until adequate safety measures were taken.

The court was told that on the day of the incident Mr Sewell was using the dumper to take loads of oversized material from one part of the centre to another. The extensive site sits in a steeply sided valley. At one point he stopped at the top of the site to deal with a customer before setting off in his empty dumper down to the bottom of the site along the main dirt track. 

The customer noted the truck was going at speed and that Mr Sewell was not wearing the seat belt. Minutes later, a colleague at the bottom of the site noticed smoke rising from a section of the dirt track above where he was working and he could just see the overturned dumper. He rushed to the scene and found Ben lying on his back at the side of the track some ten metres from the dumper truck. 

Paramedics later confirmed he had been fatally injured. 

HSE found a series of safety failings with other dumper trucks, a tracked excavator and with processing machinery for rock crushing and screening. Tipping operations were also unsafe and some of the roadways about the site were inadequately protected. Inspectors issued two Improvement Notices requiring safety changes to the site’s roadways and tipping safety measures. 

Having taken into account the current financial circumstances of the defendant Company, the Judge – His Justice, Judge Dingemans ordered Dittisham Recycling Centre Ltd, of Dittisham Cross, near Dartmouth, South Devon, to pay a fine of £50,000 and also ordered them to pay £25,000 towards the prosecutions costs (all payable over the next 5 years) for breaching Section 2(1) of the Health and Safety at Work etc Act 1974. The company had pleaded guilty at an earlier hearing. 

After the case, HSE inspector David Cory said: “Ben’s death was entirely preventable. The lack of competent training, poor monitoring and inadequate supervision of staff added up to a fatal combination. Although there were no witnesses, his injuries were consistent with being thrown from the truck. 

“Dumper trucks are inherently unstable and dangerous machines to operate and the company had not enforced the necessary rules to make sure they were driven safely, including the full and proper use of the seat lap belts. Just under a third of all fatalities in the waste sector over the last five years have involved vehicles. 

“If a vehicle has a roll over bar fitted to it the driver will also always need to use the seat belt – the safety place in an overturn is securely in the driver’s seat, protected by the roll over bar and seat belt. Many people think they can jump clear but this is wrong. Roll overs just happen too fast and they get injured or killed by the vehicle as the try to jump clear.

“Dittisham Recycling knew about the importance of having staff competently trained. It had used an external trainer for staff in the past but had not done so for Ben or one of his colleagues at the time. Instead they relied upon in-house verbal and basic hands-on training, which was inadequate. 

“Had Dittisham Recycling ensured staff were sufficiently trained, equipment was properly used and the legally-required and frankly common sense safety rules enforced – especially for dumpers – then Ben Sewell would most likely be still be alive.” 

“Ben’s mother Anna Sewell had previously told the HSE that ‘Ben was our only son and his death has left a massive hole in our lives – our house was always full of life. From the day of his death to the day of his funeral life was just a blur. It was all very distressing’. Our memories of Ben will never go away.” 

Visit http://www.hse.gov.uk/waste/safety-topic.htm for guidance on safety in the waste industry.

Notes to Editors: 

  1. The Health and Safety Executive is Britain’s national regulator for workplace health and safety. It aims to reduce work-related death, injury and ill health. It does so through research, information and advice; promoting training; new or revised regulations and codes of practice; and working with local authority partners by inspection, investigation and enforcement. www.hse.gov.uk 
  2. Section 2(1) of the Health and Safety at Work etc Act 1974 states: “It shall be the duty of every employer to ensure, so far as is reasonably practicable, the health, safety and welfare at work of all his employees.” 
  3. HSE news releases are available at http://press.hse.gov.uk/.

Article source: http://press.hse.gov.uk/2015/death-of-young-worker-leads-to-court-for-recycling-company/